Your authorized dealer has the proper oil to suit your requirements. Only genuine Harley-Davidson items designed specifically for the motorcycle model should be used with proper installation. If the fluid level can be seen, it is adequate. Check front fork for proper bearing adjustment and lubricate bearings at proper intervals. If you want to perform full scale servicing or repairs on your Harley, then choose from our range of expert-written repair manuals.
Service Departments When the motorcycle is to be left at a Harley-Davidson dealer, there are two options: Leave an assigned fob with the dealer. Upshift Acceleration Refer to Upshift Acceleration Gear Speeds: Six Speed. Inspect shock absorbers and rubber bushings for leaks and bushing deterioration at proper intervals. See the Accessory and Cargo section in your Owner's Manual. The range of a pager can be up to 0. Failure to do so could result in damage to the motorcycle electrical system. Harley-Davidson Motor Company warrants that this vehicle is designed and built so as to conform at the time of sale with applicable regulations of the U.
This will allow the engine to warm up and let oil reach all surfaces needing lubrication. Brake line contains air bubbles. Open Tour-Pak to move passenger seat backrest out of the way. The voltmeter test provides a general indicator of battery condition. Harley-Davidson Motor Company warrants that this vehicle is designed and built so as to conform at the time of sale with applicable regulations of the U. As testament to its success, Harley-Davidson has survived many ownership changes and is considered to be the fifth-largest motorcycle manufacturer in the world. Pulling on electrical wires may damage the internal conductor causing high resistance, which may result in minor or moderate injury.
Lift outside edge of cover, pivoting inside edge of cover in brackets. B-40 Tail Lamp and Directional Lamps. See a Harley-Davidson dealer for service. Push in bulb and rotate counterclockwise. This manual applies to 2002 Harley Touring models. If any electrical system trouble is experienced that might be traceable to the alternator or voltage regulator, the motorcycle should be taken to a Harley-Davidson dealer who has the necessary electrical testing equipment to give the required attention. The speedometer registers miles per hour U.
Radio fuses are located in the fuse block under the left side cover. Brakes Do Not Hold Normally Master cylinder low on fluid. The results of such abuse will be a damaged or broken shifter mechanism. Be sure the booster vehicle has a 12 Volt system. Optional Smart Siren Deactivate the Alarm Key Fob: Bring the fob to the motorcycle. Improper storage procedures can lead to equipment damage. Additionally, it includes all electrical and electronic troubleshooting.
Rolling the throttle before starting the motorcycle is unnecessary. These features may be available as accessories for your Harley-Davidson motorcycle. The standard brake system is operational, but wheel lock up can occur. Harley-Davidson Service Manuals Please visit our brand new to see a complete list of all available Harley Davidson motorcycle service manuals. Therefore, the rider must be responsible for safe operation of the motorcycle when installing accessories or carrying additional weight.
Wear a helmet, eye protection and protective clothing. If the engine lamp comes on at any other time, see a Harley-Davidson dealer. Remove left saddlebag and side cover. Use of certain other manufacturer's performance parts will void your new motorcycle warranty. Disassemble, lubricate and inspect every 50,000 miles 80,000 kilometers. For electrical problems, it is best to see a Harley-Davidson dealer who has necessary parts and equipment to perform electrical services.
Cleaning Your Motorcycle To aid you in keeping your motorcycle clean, see your Harley-Davidson dealer for cleaning, polishing and waxing products. The transmission fluid capacity is approximately 32 fluid ounces 0. While riding, a loose seat can shift causing loss of control, which could result in death or serious injury. Wear a protective face shield, rubberized gloves and protective clothing when working with batteries. Firmly push front of seat downward and then forward until slot engages tongue on rear fuel tank bracket. The transmission is now in first gear.
Shift to first gear using the gear shifter lever. The Road King utilizes the famous Big Twin engine and has distinguishable modern features like side bags, air suspension and full fairings. With hundreds of pages, it will show you how to distinguish any problem from an oil change to a transmission swap and how to fix it on your own. Brake lamps are on constantly. Be sure tires are properly inflated, balanced and have adequate tread. Riding with excessively worn, unbalanced or under-inflated tires can adversely affect stability and handling, which could result in death or serious injury.
They operate, steer, handle and brake differently. Improper tire service can adversely affect stability and handling, which could result in death or serious injury. Spark plug cables in bad condition and leaking. Insert the dipstick and tighten into the fill spout. Before moving to a new position, remove plastic plugs from holes in the footrest mount in the frame as necessary. Insert a coin or the blade of a small screwdriver into the notch at the bottom of the lens cap.