Remove the bottom pan from the transmission to drain the transmission fluid out of your Chevrolet pick up trucks transmission, clean the pan out carefully, replace the transmission filter, Install the new gasket, and both the transmission pan back in place. TruckCabinFilter selectedCabinList, null ; truckCabinFilter. Be careful not to overfill the transmission when you put transmission fluid in it, as it may cause damage. Answer: 2 From your description I would suspect that the engagement hub has sheered off the gear, this is what the synchronizer slider would lock onto that allows it to pull in 2 nd gear. BodyTypeFilter selectedBodyTypeGroupIdList, bodyTypeGroupIdToNameMap, null ; bodyTypeFilter. TruckCabinFilter selectedCabinList, null ; truckCabinFilter.
At times I really have to shove the gear shift into 1st gear when stopped. Could not repeat 4X problem and the system errors disappeared. The dealer seemed to know of this problem. To get the correct parts the first time you should disassemble the unit prior to ordering parts. When you install the clutch be sure you install the disc properly, you would not believe how many people get it backwards.
Since 1919, Standard Motor Products has engineered a full line of engine management products, including ignition parts, sensors and on-board computers. The 1991 Chevrolet K1500 has several models of engines available, depending on the needs of the driver. They are all a little bit different, but the procedure is the same when you want to change the transmission fluid and filter. They offer excellent performance capabilities when you're towing trailers or hauling heavy gear, and you enjoy smooth gear transitions without losing power. I believe this was old problem. FuelTypeFilter selectedFuelTypeList, null ; fuelTypeFilter. Since 1918, Dorman Products has supplied the automotive aftermarket with high-quality replacement parts, hardware and fasteners.
Walker Products supplies the automotive aftermarket with premium engine sensors and fuel system components. DealRatingFilter selectedRatingList, null ; ratingFilter. FuelTypeFilter selectedFuelTypeList, null ; fuelTypeFilter. If you need help, just call the drivetrain experts 1-888-824-2012. SellerTypeFilter selectedSellerTypeList, null ; sellerTypeFilter.
BodyTypeFilter selectedBodyTypeGroupIdList, bodyTypeGroupIdToNameMap, null ; bodyTypeFilter. Browse these listings for your restoration parts and accessories such as this AutoTrust Platinum Speed Sensor! Worn synchro rings can result in gear clash when going into forward gears though they can stick somewhat in new or recently rebuilt transmissions, leading to hard or noisy shifting, which gets better as the rings wear in. Message was only displayed in 2wd mode. Also replace the ends of 3 trans hoses. Hard shifting, noise, wear, and internal binding are usually caused by lubricant issues — dirty gear oil, low levels, or the wrong lubricant. The standard length of the 1991 Chevrolet K1500 is 194 inches; however, the extended cab model has a length of 213.
The reaction plates have a tendency to break and cause the sloppy symptom you are describing. DealRatingFilter selectedRatingList, null ; ratingFilter. Have been playing with this transmission for the past three years trying to figure out why the system is so erratic. All Replacement brand items are backed by 1-year, unlimited-mileage warranty. The 1991 Chevrolet K1500 has three engine options. The standard cab seats three people, while the extended cab can seat up to six.
Both the standard and extended cabs have either rear two-wheel drive or four-wheel drive. With the assembly out you can inspect the reaction plate and determine if this is the problem. They are great, honest people to work with when buying your next vehicle. If a leak shows up at the rear of the extension or adapter housing, it is likely from the housing seals; if it shows up at the front, it could be the front bearing retainer or the retainer seal. InstalledOptionsFilter selectedInstalledOptionIdList, installedOptionIdToLabelMap, possiblyDroppedOptionsMap ; installedOptionsFilter.
The K1500 is Chevrolet's half-ton series which are available in both a short bed and a long bed. We also offer rebuilt units and parts. Gets worse once the truck has warmed up. The transmission fluid was drained and flushed, the filter changed, and a new transmission fluid added. Scraping noise heard when applying brakes. AutoTrust Platinum supplies a growing selection of low-priced transmission and shifter components! This is a direct replacement to your original factory unit.
. Once you get it apart give us a call toll free and we can review any parts that are damaged with you to ensure you get the correct parts to fix this problem. To repair this problem it would require the transmission to be taken out and disassembled in order to do the repair. Will have to replace pump and get new half of the t-case housing next time it happens. Both models come with either a six and one-half-foot or eight-foot beds. Other leaks, where components meet, could be due to problems with the sealer or incorrect bolt tightening.