Pull the plug and let drain, be sure to clean bolt off, it has a magnet on it to pick up debrie from transmission. Sell the o'le under powered four-banger and get the six. For 1979 through 1981, there was also an Audi 2. If the leak stops it wasn't a bad pump after all, was it? The output for the front drive shaft is on the left side. Interchange 'flip' is possible, but there is an indexing lug in the pattern, in an attempt to allow the transfer case to attach in only one position. The is an transmission that connects the front and rear.
We'll know tomorrow with the hose replacement. If you take your Jeep in regularly to have the oil changed, you can also have the service technician check the transmission fluid levels for you. Most vehicles built with a Dana 18 have the rear axle offset to the right side to accommodate this. Transmissions are arranged by the most recently introduced transmissions first. Depends on what Chrysler recommends, check your owners manual for the recommended fluids. This article needs additional citations for. Rear-wheel-drive-only transmissions all have the same spline count on the output shaft, only 4x4 models are affected by differing spline count.
It was a significantly new design with a wider track, slightly less , more comfort and improved handling. Also, in 1992, the Sahara debuted. This manual will have step by step instructions and illustrations. This article may require to meet Wikipedia's. Starting in 1991, a 180 hp 134 kW 4. The output for the front drive shaft is on the right side and the rear output is in line with the input.
It will take the 1st time home mechanic a day or two to do this job. The 1989 Jeep Wrangler featured air conditioning and a tape deck as options. The third digit indicates differential type: 1 means locked no differential , 2 means open, 3 means electric locked, 4 and 5 both indicate an split gear and gear drive, 6 means an electronic clutch pack, 7 means a clutch pack except for the unique 207 , and 9 means a coupler. It is a heavy-duty, gear-driven transfer case with a 23-spline input shaft. Both have their strengths and weaknesses, but it seems that most off-roaders have come down on the side of the manual transmissions. However, they are a bit heavier, which may make them less attractive for less aggressive forms of the sports.
The wiring harness, radiator, computer, and the engine mounts will all have to be changed. Almost all Dana 18 and Dana 20 input gears are 6-spline; the only exception is the one used with the 10-spline version of the T14 transmission. You will have to figure out how to mate the tranny and transfer case. The Dana 18 always has gears turning, which makes it noisier then some other transfer cases when in two-wheel-drive mode. The output for the front drive shaft is on the right side and the rear output in line with the input.
Remove this plug and fill it until trans lube runs out. The flywheel also changed from 153 teeth a common Chevy size to 164 teeth a common Ford size. The water pump is behind the cover that the serpentine belt runs under? Under the Jeep on the upper side of the transmission you will see a plug. I dont think you have to take the radiator out, but the water pump should be visible directly behind it. Aisin Warner originally built this transmission to be strong enough to handle the abuse that Jeeps have been known to handle, we have been able to honor this tradition and even taken a step farther with our state-of-the-art build process. Truck freight and oversize charges still apply unless otherwise noted, and can only be shipped to the lower 48 States. The 1980 factory original came with a shorter tail housing and a longer rear drive shaft.
For Jeep Four-Wheel drive systems by tradename, see. That cost would depend on where you take it. I had to take my skid plate off to get to it easier. Shipping to Alaska and Hawaii will require an additional charge. This engine provided 177 horsepower and 224 foot-pounds of torque. There are no Jeep Wranglers with amenities such as power locks, seats or windows.
Add about 3 to 4 quarts Depending on size of transmission,start engine check fluid level while engine is running should let it warm up Add fluid as needed to fill to full line. Check with auto parts store to get correct type. Free Shipping Offers are for Standard Ground Delivery Service and are only valid for shipping addresses within the 48 contiguous United States. They should be able to tell you how many quarts your car requires. Caution: Be sure you use the correct lube. Not to mention possibly the gas tank and fuel pump, bc some years they ran at different fuel pressures.
It shares many parts with the Aisin that is used in Toyota off-road vehicles. The Laredo hard top featured a 4. Most other transfer cases used in Jeeps have a centered rear output that lines up with the input shaft. Follow these steps to make sure your transmission fluid is at the proper level. The 23-spline was universal in the lines and was generally used with six-cylinder applications.